UPK596BW-T7.2

UPK599AHW2

主要產品：日本東方馬達，韓國DKM減速電機，泰映TROY減速電機，韓國SPG小功率

馬達，CPG晟邦減速電機 ...

減速機技術資料：

蝸輪減速機是常見的一種減速機，它的特點鮮明、使用方便，深受使用者的青睞。蝸輪減速機的安裝是非常細致的工作，在安裝過程中應注意操作的細節，保證蝸輪減速機的安裝效果。

            一、蝸輪減速機的特點

            1、蝸輪減速機的機型小巧、機構緊湊、重量較輕、占用空間少、散熱性能優良、承載能力大，適合在復雜的工況中使用。

            2、蝸輪減速機的減速比大，使用范圍廣泛，具有自鎖特性，對于起重設備尤其適用，在起重設備停機時即可自鎖，保證重物不會受重力影響而自行下落。

            3、蝸輪減速機的傳動平穩、運行可靠、沖擊小、噪音低、與其他機械組合能力強、適應性好，并能獲得較大傳動比。

            4、蝸輪減速機的蝸輪輸出具備中空輸出軸結構，可以配合單側出力軸和雙側出力軸，在搭配輸入輸出方式上具有較高靈活性。

            二、蝸輪減速機的安裝注意

            1、蝸輪減速機必須安放在平整平面上，用地腳螺栓進行固定，保證蝸輪減速機的平衡、穩定及牢固。

            2、蝸輪減速機要保持封閉安裝，潤滑方式為油浸潤滑，潤滑油量應保持在視鏡中心線下6mm水平面，在蝸輪減速機開始運行之后，每季度都應檢查潤滑油使用量，并及時補充或更換潤滑油。

            3、蝸輪減速機在安裝后要進行安裝檢查，例如是否存在泄漏、松動等異常情況，確認無異常后，開始試運行，試運行正常后則進入正常使用。

            4、蝸輪減速機的蝸桿轉速不能超過每分鐘1500轉，至于旋轉方向沒有特別限制，可以根據用戶需要自行調節。

            5、蝸輪減速機的工作環境應保持溫度在±40℃以內，在工作環境保持在20℃上下時，負載正常溫度上限為80℃。


Rorze FABS-202 Wafer Transfer Station IVRR8150-W01-006 

Semitool 610T0290-01 Transfer Robot new

Daifuku Pod Opener Loadport PO-125M0016 Working

Semitool 610T0348-503 Transfer Robot not working as-is

Rorze Robot Controller CURR-3265-1 new 0190-04678

Kensington Labs 25-3700-1425-08 Robot and Controller Se

Genmark 300mm Robot Wafer Prealigner Working

Genmark Classic Transfer Robot working

Genmark Automation Robot Controller S08R v.11 working

Genmark Robot Controller SMALL 990010622A1 working

Genmark Automation Robot Controller S08P4.RD working

MECS Corp. UTV-2500H Robot Controller CS-7000 working

Equipe Technologies ESC-200-S293 Robot Controller teste

Equipe Technologies ABM-407B-1-S-CE-S293 Transfer Robot

Rorze 300mm Prealigner AA00156 working RA301-812-003

PRI Automation ABM-407B-1-S-CE-S293 Transfer Robot 0000

MECS Transfer Robot Track YC505 working

Nikon 4K177-955-2 Robot Handler from Nikon NSR S204B Us

Nikon Robot Handler 4K177-955-1 Nikon NSR S204B Working

Jenoptik Infab 300mm Wafer Load Port Fixload 25TM worki

Berkeley Process BX-2 Controller 100-000-928 0190-00304

MECS UTX-5000 Robot Controller CS-7000 untested

Mactronix Wafer Prealigner Handler Sorter AWI-600 worki

ASM Epsilon Genmark Robot System Controller 9800106571

MECS Corp. Wafer Prealigner AL100 untested

MECS Corp. Prealigner AL100 untested

Tazmo Co. HS33 Transfer Robot Controller HS334A070 work

Kensington Robot Track Controller 25-4061-006-00 0190-1

Microvision Prealigner MVT3080  Working

AMAT Cartesian Robot Z Axis Front Mast Bars 0190-27401

Berkeley Process 300mm Prealigner 100-000-871-02 new 90

Genmark Precision Automated Transfer Robot working

Cybeq 2831 Control Unit Controller refurbished

Rorze Robot Linear Track and Controller RT107-1201-002

Berkeley Process Control Prealigner 100-000-871-02

Equipe Technologies ESC-100 Robot Controller working Op

MECS OF101 Robot Controller working

PRI ABM-407B-1-S-CE-S293 Transfer Robot 0014446-000 dam

PRI Automation ATM-407B-1-S Transfer Robot not working 

PRI Automation ABM-407BF-1-S-FSD-LHS Transfer Robot not

Berkeley Process 300mm Prealigner 100-000-871-02

Synetics End Effector UK-9240-06310-D new 9240-06310

Synetics End Effector UK-9240-06174-C new 9240-06174

Accu-Fab Systems Accubot Transfer Robot untested

MECS CS-7000 Robot Controller UTV-F2500H untested

MECS Transfer Robot UTVF2500H untested

MicroVision Corp. MVT-5080 Robot 740-300-061 working

Oerlikon Unaxis 300mm End Effector 102104213 new
Rorze 200mm Indexer Elevator RE120-002-001

Rorze Indexer Elevator Assy. 200mm RE120-002-001

MECS SB-100A Teach Pendant working

Rorze Automation Robot Linear Track RT107-1201-002

ASQ 200mm Wafer Transfer Machine AT2S8-25 working

Cymer Teach Pendant 16-13000-00 working

Cymer Oyster Technologies 05-13001-00 Teach Pendant wor

Cymer Oyster Technologies Teach Pendant 05-13002-00

Lion Precision E Series Controller Cabinet-7E working M

Rorze Transfer Robot Wrist Block 0190-04680 new

Millipore Photo-250 Teach Pendant W2501KP01

Quantum Robot Teach Pendant 8030R2-H-LM-AMAT

Quantum Robot Teach Pendant 8030EKR2-H-LM-Applied

Quantum Teach Pendant 8030EKR2-H-LM-APPLIED working

Quantum Remote Teach Pendant 8030EKR2-H working

Kepco 0024782 Robot Power Supply 27-053701-00 working

Rorze Dual Arm Robot RR711L1521-3A3-E11-1 untested

Tenta DIDO Board T002-00710 Rev. B  Working

TVL Tokyo Electron Varian Ltd Teach Pendant E1657A

Leybold Cable Turbo Pump 86021-001-3M New

Berkeley Process 2-Axis Stepper Motor Interface BAM-ST

Lot of 5 LTD Ceramics Robot End Effector 620T0024-01 

Daifuku RM/TFE/CONV. AGH8AA10 Controler Working

Cymer 06-13000-00 Teach Pendant  working

Equipe Brooks Pri 2002-0031-07SCE Robot Cable 2002-00

Berkeley Process BX2 71CO0118 Cable Kit 300-004-084 new

Rorze 2P Micro Step Driver RD-023MS Pair 

Rorze Master Controller RC-204A

Equipe Robot End Effector 47900058 New

Semitool 610T0290-01 Transfer Robot new

Kensington Labs 25-3700-1425-08 Robot and Controller Se...

Daifuku Pod Opener Loadport PO-125M0016 

Semitool 610T0348-503 Transfer Robot not  as-is

Equipe Technologies ABM-407B-1-S-CE-S293 Transfer Robot...

PRI Automation ABM-407B-1-S-CE-S293 Transfer Robot 0000...

Nikon 4K177-955-2 Robot Handler from Nikon NSR S204B Us...

Nikon Robot Handler 4K177-955-1 Nikon NSR S204B 

Jenoptik Infab 300mm Wafer Load Port Fixload 25TM worki...

Accu-Fab Systems Accubot Transfer Robot untested

Mactronix Wafer Prealigner Handler Sorter AWI-600 worki...

Tazmo Co. HS33 Transfer Robot Controller HS334A070 work...

Kensington Robot Track Controller 25-4061-006-00 0190-1...

Microvision Prealigner MVT3080 

AMAT Cartesian Robot Z Axis Front Mast Bars 0190-27401

Cybeq 2831 Control Unit Controller refurbished

PRI ABM-407B-1-S-CE-S293 Transfer Robot 0014446-000 dam...

PRI Automation ATM-407B-1-S Transfer Robot not  ...

PRI Automation ABM-407BF-1-S-FSD-LHS Transfer Robot not...

Equipe Technologies ESC-100 Robot Controller  Op...

Synetics End Effector UK-9240-06310-D new 9240-06310

Synetics End Effector UK-9240-06174-C new 9240-06174

MicroVision Corp. MVT-5080 Robot 740-300-061 

Oerlikon Unaxis 300mm End Effector 102104213 new

Leybold Cable Turbo Pump 86021-001-3M New

ASQ 200mm Wafer Transfer Machine AT2S8-25 

Transfer Robot End Effector Assembly 950130MU5A 950130M...

Cymer Teach Pendant 16-13000-00 

Cymer Oyster Technologies 05-13001-00 Teach Pendant wor...

Cymer Oyster Technologies Teach Pendant 05-13002-00

Lion Precision E Series Controller MOD CAB  MM1 ...

Lion Precision E Series Controller Cabinet-7E  M...

Millipore Photo-250 Teach Pendant W2501KP01

Quantum Robot Teach Pendant 8030R2-H-LM-AMAT

Quantum Robot Teach Pendant 8030EKR2-H-LM-Applied

Quantum Teach Pendant 8030EKR2-H-LM-APPLIED 

Quantum Remote Teach Pendant 8030EKR2-H 

Kepco 0024782 Robot Power Supply 27-053701-00 

Tenta DIDO Board T002-00710 Rev. B 

TVL Tokyo Electron Varian Ltd Teach Pendant E1657A

Lot of 5 LTD Ceramics Robot End Effector 620T0024-01 

Daifuku RM/TFE/CONV. AGH8AA10 Controler 

Cymer 06-13000-00 Teach Pendant 

Equipe Robot End Effector 47900058 New

Equipe Brooks Pri 2002-0031-07SCE Robot Cable 2002-00...