CSK264-AP

CSK264AP-SG10

主要產品：日本東方馬達，韓國DKM減速電機，泰映TROY減速電機，韓國SPG小功率

馬達，CPG晟邦減速電機 ...

銷售熱線: 180-6090-9625/0592-6013512

聯系人：蘭工

      QQ: 869740621

減速機技術資料：

蝸輪減速機常見問題分析
     蝸輪蝸桿減速機作為一個傳統的傳動裝置，內部是渦輪蝸桿，齒形是漸開線的。很多的蝸輪減速機使用者對蝸輪減速機的了解情況是少之又少的，更不要說對于一些常見問題的分析了，下面我們就和大家一起來了解下蝸輪減速機常見問題分析。

一、常見問題及其原因

1．減速機發熱和漏油。為了提高效率，蝸輪減速機一般均采用有色金屬做蝸輪，蝸桿則采用較硬的鋼材。由于是滑動摩擦傳動，運行中會產生較多的熱量，使減速機各零件和密封之間熱膨脹產生差異，從而在各配合面形成間隙，潤滑油液由于溫度的升高變稀，易造成泄漏。 造成這種情況的原因主要有四點，一是材質的搭配不合理；二是嚙合摩擦面表面的質量差；三是潤滑油添加量的選擇不正確；四是裝配質量和使用環境差。

2．蝸輪磨損。蝸輪一般采用錫青銅，配對的蝸桿材料用45鋼淬硬至HRC4555，或40Cr淬硬HRC5055后經蝸桿磨床磨削至粗糙度Ra0.8μm。減速機正常運行時磨損很慢，某些減速機可以使用10年以上。如果磨損速度較快，就要考慮選型是否正確，是否超負荷運行，以及蝸輪蝸桿的材質、裝配質量或使用環境等原因。

3．傳動小斜齒輪磨損。一般發生在立式安裝的減速機上，主要與潤滑油的添加量和油品種有關。立式安裝時，很容易造成潤滑油量不足，減速機停止運轉時，電機和減速機間傳動齒輪油流失，齒輪得不到應有的潤滑保護。減速機啟動時，齒輪由于得不到有效潤滑導致機械磨損甚至損壞。

4．蝸桿軸承損壞。發生故障時，即使減速箱密封良好，還是經常發現減速機內的齒輪油被乳化，軸承生銹、腐蝕、損壞。這是因?yàn)闇p速機在運行一段時間后，齒輪油溫度升高又冷卻后產生的凝結水與水混合。當然，也與軸承質量及裝配工藝密切相關。

二、解決方法

1．保證裝配質量。可購買或自制一些專用工具，拆卸和安裝減速機部件時，盡量避免用錘子等其他工具敲擊；更換齒輪、蝸輪蝸桿時，盡量選用原廠配件和成對更換；裝配輸出軸時，要注意公差配合；要使用防粘劑或紅丹油保護空心軸，防止磨損生銹或配合面積垢，維修時難拆卸。

2．潤滑油和添加劑的選用。蝸齒減速機一般選用220#齒輪油，對重負荷、啟動頻繁、使用環境較差的減速機，可選用一些潤滑油添加劑，使減速機在停止運轉時齒輪油依然附著在齒輪表面，形成保護膜，防止重負荷、低速、高轉矩和啟動時金屬間的直接接觸。添加劑中含有密封圈調節劑和抗漏劑，使密封圈保持柔軟和彈性，有效減少潤滑油泄漏。

3．減速機安裝位置的選擇。位置允許的情況下，盡量不采用立式安裝。立式安裝時，潤滑油的添加量要比水平安裝多很多，易造成減速機發熱和漏油。

4．建立潤滑維護制度。可根據潤滑工作“五定”原則對減速機進行維護，做到每一臺減速機都有責任人定期檢查，發現溫升明顯，超過40℃或油溫超過80℃，油的質量下降或油中發現較多的銅粉以及產生不正常的噪聲等現象時，要立即停止使用，及時檢修，排除故障，更換潤滑油。加油時，要注意油量，保證減速機得到正確的潤滑。還可以選用齒輪箱清洗維護機利用齒輪箱原有的給排油系統以及過濾后的潤滑油對齒輪箱進行清洗，不改變齒輪箱任何硬件設施、不添加任何清洗劑，保證了齒輪箱安全運營，延長了齒輪箱的使用壽命。


Reliance Electric Flex Pak Plus Drive 14C520

NEW RELIANCE ELECTRIC 0-51845-1 PRINTED CIRCUIT 

RELIANCE ELECTRIC RECTIFIER STACK 86474-IS

Reliance Electric GP-2000 AC V-S Drive 3HP New

Reliance Electric 51865-9 Circuit Board

RELIANCE ELECTRIC P2865276D 25-HP 841XL 3-PH 3550-RPM 0284TS-FR ELECTRIC MOTOR

RELIANCE ELECTRIC COUPLING 400821-18A

Reliance Electric Printed Circuit Loop Card 0-51865-9 

Reliance Electric Thyristor 86466-12R

RELIANCE ELECTRIC 809'53-00 CIRCUIT CARD


Reliance Electric Drive GP-1200 1AC4103U-RP-012 4.2 KVA 3 HP 460 V

Enlarge
RELIANCE ELECTRIC 0-49020-4 0490204 CONTROLLER CARD NEW

NEW RELIANCE ELECTRIC DC2-42UF VS DRIVE 

Reliance Electric Motor P14G9258_2HP_IP44_60 Hz_1750 RPM_Class F_Des B


RELIANCE ELECTRIC MOTOR HAZARDOUS EXPLOSION PROOF P18G1183A 182TC 3 HP 3 PH NEW

RELIANCE ELECTRIC O-48664-2 O486642 0-48664-2 VLTG TRANSDUCTOR NEW

NIB RELIANCE ELECTRIC 69326-31R CONTROL RELAY MODULE 6932631R


NEW RELIANCE ELECTRIC 602909-68AE TRANSISTOR 60290968AE

NEW RELIANCE ELECTRIC 0-52012-3 DRIVER BOARD

RELIANCE ELECTRIC AC DRIVE VARIABLE SPEED GP-2000 "NEW"

RELIANCE ELECTRIC PRINTED CIRCUIT AUX M KIT 0543791

Reliance Electric 0-57412-D DCS Field Regulator

NEW RELIANCE ELECTRIC B-57300 CIRCUIT BOARD MODULE PLC CARD 54758

NEW RELIANCE ELECTRIC 57C409 2-CHANNEL ANALOG INPUT MODULE PLC 15V DC REV 55043

RELIANCE ELECTRIC AC VS DRIVE GP-2000 CONTROL PANEL

RELIANCE ELECTRIC 1SU51007 SP500 7 1/2 HP. GOOD DRIVE

Reliance Electric Semikron 701819102AW Diode | NEW NIB


RELIANCE ELECTRIC ETR 38 90 POWER SOURCE BOILER PRECEPITATION BOARD TB800 58223

RELIANCE ELECTRIC ETR 51 52 TB600 POWER SOURCE BOILER PRECIPITATION BOARD 58224

NEW RELIANCE ELECTRIC LIMIT MODULE CARDPAK 0-49008-3


Baldor Reliance industrial pump motor 3hp M8A 103049270-001 M36K77-2759

RELIANCE ELECTRIC 57C-409 INPUT MODULE (1933)

Reliance Electric 756H109AA-ST Power Matched DC Motor


Reliance Electric Printed Circuit Gate Coupling Card w/ 700874-66A 0-51378-6 NIB

RELIANCE ELECTRIC 0-51851 CRCA CONTROLLER NEW SURPLUS


Reliance Electric LSCA Board 0-51884 #34551

Reliance Electric 0-49040 Cardpak Controlled Rectifier 

1 NEW RELIANCE ELECTRIC DUTY MASTER A-C MOTOR 

Reliance Electric IMPakPlus VS Drive 

RELIANCE ELECTRIC DISTRIBUTED CONTROL SYSTEM RESOLVER INPUT 57411-2C

NEW RELIANCE ELECTRIC VSDRIVE SP500 EASY CLEAN PLUS


Reliance Electric 0-51863 

ALLWEILER AS0102 EW2 PUMP WITH RELIANCE 1HP AC MOTOR

RELIANCE ELECTRIC DRIVE DIGITAL I/O MODULE 57401-2

Reliance Electric HR2000 / BLA-08 Brushless AC Servo 

RELIANCE ELECTRIC 0-55325-9 PRINTED CIRCUIT VOLTAGE TO ISOLATOR MODULE 56915

RELIANCE ELECTRIC GV3000 AC DRIVE 1V2150

RELIANCE ELECTRIC 57402-D 115VAC/DC OUTPUT MODULE 16 CHANNEL M/N 57C402 QUANTITY

Reliance Electric AC VS Drive GS-2000 200/230 VAC 3 Phase 2Hp 2GU21002 + In/Out

RELIANCE ELECTRIC 1.7KVA 1HP VARIABLE SPEED AC DRIVE 1AC2001 *LOT OF 3*

RELIANCE ELECTRIC HR2000/BLA-08 SERVO DRIVE GOOD TAKEOUT


RELIANCE ELECTRIC 14C109A FLEXPAK PLUS 5 HP GOOD TAKEOUT

RELIANCE ELECTRIC HR2000/BLA-16 SERVO DRIVE GOOD TAKEOUT


RELIANCE ELECTRIC SP 500 VS DRIVE 1SU41002 (2 HP)

RELIANCE ELECTRIC HR2000/BLA-12 SERVO DRIVE GOOD TAKEOUT


Reliance Electric Flexpak Plus VS Drive 40HP.....

RELIANCE ELECTRIC 57456-B 115VAC INPUT MODULE 16-CHANNEL M/N 61C500

RELIANCE ELECTRIC 45C-968 USPP 45C968

VERY NICE RELIANCE ELECTRIC HVAC FREQUENCY DRIVE VTAC7

RELIANCE ELECTRIC AUTOMATE 45C1 I/O RAIL W/ 8 MODULES 1

New Reliance Electric Single Phase Motor C56H3681M 1/3HP 1140RPM FRAME:FJ56C


New Reliance Electric Digital Meter 9C112 3.5 Digit DPM 35 BP


Reliance Electric IRCG Board 0-51839-6 #34574

Used Reliance Electric VS Drive SP500 1SU44003 3HP Drive 380-460VAC 3PH 6.4A

RELIANCE ELECTRIC 0-57408-1C Interface Mod 574081C New

Reliance Electric CVTB Board 0-51831-1 #34555

Reliance Electric MasterXL Speed Reducer 56CM12A 192 Ratio, 1750RPM

Reliance Electric Master XL Speed Reducer 56WM16A Ratio 30, 1750RPM

SC-165, RELIANCE ELECTRIC 20 HP MOTOR

Reliance Electric Comp. AC Motor P56A1337W-UZ 3/4HP 1725RPM

RELIANCE ELECTRIC 57457-B 24VAC/DC INPUT MODULE M/N 61C515 QUANTITY!!

RELIANCE ELECTRIC 77801-18KXX NSFP 7780118KXX

RELIANCE ELECTRIC 0-49001-5 USPP 0490015

1 HP 1800 RPM Reliance ULTRA KLEEN Stainless Steel Electric Motor

Reliance Electric 57405-E 0- 57405E Analog I/O Drive Module - Used


Reliance Electric 0-51865-2 PC Board CLDC 0518652

RELIANCE ELECTRIC 0-57516-1 USPP 0575161

RELIANCE ELECTRIC 57C-331 USPP 57C331

Reliance Electric 104042 Flange Block Non-Exp Dodge Type C 

RELIANCE ELECTRIC A77B5902P NSPP A77B5902P

RELIANCE ELECTRIC 401286-15P USPP 40128615P

RELIANCE ELECTRIC A77B5901N-AA NSPP A77B5901NAA

RELIANCE ELECTRIC 9C111 USPP 9C111

RELIANCE ELECTRIC 9C-112 USPP 9C112

RELIANCE ELECTRIC 0-52524 NSPP 052524

RELIANCE ELECTRIC 45C901 USPP 45C901

1 NIB RELIANCE ELECTRIC T56S1019B 1/4 HP DC MOTOR 1750 RPM


1 NIB RELIANCE ELECTRIC 0-57400-1 0574001 INPUT MODULE


RELIANCE ELECTRIC 608870-31R USPP 60887031R

RELIANCE ELECTRIC 64670-6RX NSPP 646706RX

NIB RELIANCE ELECTRIC 613613-40S 61361340S FIBER OPTIC
CABLE


Reliance Electric 8K Memory # 45C270


1 NIB RELIANCE ELECTRIC 613613-27S OPTIC CABL 61361327S


1 NIB RELIANCE ELECTRIC 613613-600R CABLE 613613600R


1 NIB RELIANCE ELECTRIC 613613-31S CABLE 61361331S


1 NIB RELIANCE ELECTRIC 613613-30S CABLE 61361330S


1 NIB RELIANCE ELECTRIC 613613-36S CABLE 61361336S


1 NIB RELIANCE ELECTRIC 613613-38S CABLE 61361338S


1 NIB RELIANCE ELECTRIC 613613-650R CABLE 613613650R


1 NIB RELIANCE ELECTRIC 613613-29S CABLE 61361329S


1 NIB RELIANCE ELECTRIC 613613-28S CABLE 61361328S


Reliance Electric Automate 45C270 8K MEMORY EXPANSION

RELIANCE ELECTRIC 64670-21R CURRENT TRANSDUCER 6467021R NEW


1 NEW RELIANCE ELECTRIC 057403F OUTPUT MODULE 16 POINT


1 NEW RELIANCE ELECTRIC 057403 OUTPUT MODULE 16 POINT


RELIANCE ELECTRIC 0-48680-300 INTERFACE MODULE 04680300


RELIANCE ELECTRIC 48267-L RESISTOR 48267L 9.420OHM NIB 


1 NEW RELIANCE ELECTRIC 0-57401-C 057401C DRIVE DIGITAL


NIB RELIANCE ELECTRIC 613613-700R 613613700R FIBER 
OPTIC CABLE


RELIANCE ELECTRIC BDC-25L SERVO CONTROL 9106-0059

NIB RELIANCE ELECTRIC 613613-41S 61361341S FIBER OPTIC
CABLE


NIB RELIANCE ELECTRIC 613613-34S 61361334S FIBER OPTIC
CABLE


RELIANCE ELECTRIC 1GA687174 (103774-64) AC DRIVE

RELIANCE ELECTRIC SP500 1SF44002 ONYX DRIVE 2HP TESTED

RELIANCE ELECTRIC 0-52835 SCSA PRINTED CIRCUIT CONTROL BOARD CARD PCB 51919

RELIANCE ELECTRIC 0-58706-2 NSPP 0587062

RELIANCE ELECTRIC 3EB1 USPP 3EB1

RELIANCE ELECTRIC AC MOTOR 20HP 460V 3PH 3530RPM L2158C 01KS502312F 18214 

RELIANCE ELECTRIC 121191-170 USPP 121191170

RELIANCE ELECTRIC 612-234-RJ NSPP 612234RJ

RELIANCE ELECTRIC 6MDAN-8P0101 NSFP 6MDAN8P0101

RELIANCE ELECTRIC 402422-3P NSPP 4024223P

RELIANCE ELECTRIC 48267-B USPP 48267B

RELIANCE ELECTRIC 64960-27R NSFP 6496027R

RELIANCE ELECTRIC A77B5901M-PR NSPP A77B5901MPR

RELIANCE ELECTRIC 0-52830 NSPP 052830

RELIANCE ELECTRIC 610266-27T NSFP 61026627T

RELIANCE ELECTRIC 9097-1094 USPP 90971094

RELIANCE ELECTRIC 0-51434-6 USPP 0514346

RELIANCE ELECTRIC 0-51447-2A USPP 0514472A

RELIANCE ELECTRIC 0-54392 USPP 054392

RELIANCE ELECTRIC 0-54392-2 USPP 0543922

Reliance Electric 0-55325-8 0553258 Circuit Board - New, No Box


RELIANCE ELECTRIC 86377-1R USPP 863771R

RELIANCE ELECTRIC 413366-1AF NSFP 4133661AF

RELIANCE ELECTRIC P18G431H USPP P18G431H

RELIANCE ELECTRIC 64690-5RA NSFP 646905RA

RELIANCE ELECTRIC 0-52014 NSFP 052014

RELIANCE ELECTRIC P14X3256T-RZ USPP P14X3256TRZ

RELIANCE ELECTRIC P14X3256T-TZ USPP P14X3256TTZ

RELIANCE ELECTRIC A77W8190M-NS USPP A77W8190MNS

RELIANCE ELECTRIC 0-57003 NSFP 057003

RELIANCE ELECTRIC MR94762 NSFP MR94762

RELIANCE ELECTRIC MR94763L1 NSFP MR94763L1

1 NIB RELIANCE ELECTRIC 45C994 OUTPUT MODULE 2 POINT ANALOG 0 - 10 V


1 NIB RELIANCE ELECTRIC 0-52823 052823 DIGITAL FIRING CIRCUIT SEALED 


1 NIB RELIANCE ELECTRIC 0-51845 051845 POWER SUPPLY BOARD


RELIANCE ELECTRIC 14C-429 USPP 14C429

NIB RELIANCE ELECTRIC S2C332A 10 SLOT RACK PANEL MOUNT


Reliance Electric Drive Analog Module 57405-D

Reliance Electric 1SU41002 SP500 VFD 2HP Speed Drive

Reliance Electric 0-56301 Base Driver 056301 New

RELIANCE ELECTRIC DC1-27 USPP DC127

RELIANCE ELECTRIC 0-52861-1 USPP 0528611

1 NIB RELIANCE ELECTRIC 0-54379-10 05437910 CARD


RELIANCE ELECTRIC 612230-R NSFP 612230R

RELIANCE ELECTRIC 0-54381 USPP 054381

RELIANCE ELECTRIC 0-51445 CONTROL BOARD ***XLNT***

RELIANCE ELECTRIC T56H1042N-SP USPP T56H1042NSP

RELIANCE ELECTRIC 0-51829-1 USPP 0518291

RELIANCE ELECTRIC 1SU20002 USPP 1SU20002

RELIANCE ELECTRIC 45C-914 NSFP 45C914

Reliance Electric 57C409/57C-409 Ser E Analog Input


Reliance Electric 57C409/57C-409 Ser D Analog Input

Reliance Electric 57C409/57C-409 Ser H Analog Input


RELIANCE ELECTRIC S20-402P0-B1000 NSFP S20402P0B1000

RELIANCE ELECTRIC T-100B USPP T100B

RELIANCE ELECTRIC 411027-20S NSFP 41102720S

Reliance Electric Drive Digital I/O Module 57401-2


Reliance Electric 3 HP VS AC Drive GP1200 1AC4103U 460V RE 1AC4103-U 3HP

RELIANCE ELECTRIC MOTOR (MOTOR ONLY) W/O ENCODER DEK 660-1A(SCR)+RM21-500-LD*M*

NEW RELIANCE ELECTRIC 0-55325-8 PC CURRENT VOLTAGE CARD 54655

Reliance Electric 01482-1079-000-10 P/N 1140-001-1729 T 

Reliance Electric M1140 P/N 1140-001-1729 

RELIANCE ELECTRIC 0-51865 CURRENT RATE/GAIN LOOP DRIVER CLDA PCB MODULE

RELIANCE ELECTRIC 8C59D IMPAK VS DC DRIVE 3HP 230V 19A

***NIB*** Reliance Electric Shark Prog. Cont. # 45C904

RELIANCE ELECTRIC P14H1447 AC MOTOR 1.5 HP NEW