UPK596BW-P36
UPK596BW-P50
主要產品：日本東方馬達，韓國DKM減速電機，泰映TROY減速電機，韓國SPG小功率
馬達，CPG晟邦減速電機 ...
銷售熱線: 180-6090-9625/0592-6013512
聯系人：蘭工
QQ: 869740621
減速機技術資料：
減速機是工業企業大量應用的設備，一旦漏油，不僅造成經濟損失，嚴重時還會引起減速機少油、斷油，使齒輪嚙合面磨損加劇，進而發生打齒或剝離，導致設備事故。減速機漏油，對周圍環境污染厲害，對基礎有腐蝕作用，這樣既破壞了文明生產又浪費了不少本可回收再生的潤滑油。減速機漏油，是減速機使用中常見的故障現象。正確分析和診斷減速機漏油的原因，并針對原因采取有效解決方法，是保證減速機正常運行、延長減速機使用壽命的關鍵。
減速機漏油的原因分析
通常情況下，造成減速機漏油主要有5個方面的原因：
1.減速機內外產生的壓力差
在封閉的減速機里，每一對齒輪相嚙合發生摩擦便要發出熱量，根據波義耳—馬略特定律，隨著運轉時間的加長，減速機箱內溫度逐漸升高，而減速機箱內體積不變，故箱體內壓力隨之增加，箱體內潤滑油經飛濺，灑在減速機箱內壁。潤滑油在壓差作用下，從縫隙處漏出。
2.減速機結構設計不合理或加工存在問題
設計的減速機沒有通風罩或窺視孔蓋上無透氣塞；軸封結構設計不合理，采用油溝、氈圈式軸封結構，由于毛氈的補償性能極差，導致密封在短時間內即失效；油溝上雖有回油孔，但極易堵塞，回油作用難以發揮。制造過程中，鑄件未進行退火或時效處理，鑄件未消除內應力，導致變形產生間隙從而發生漏油現象；存在砂眼、夾渣、氣孔、裂紋等缺陷；加工精度不良引起的漏油，由于減速機箱體配合面加工精度不高、公差不合適、裝配不符合要求等因素的存在,導致減速機可能漏油。
3.加油量過多
減速機在運轉過程中，油池被攪動得很厲害，潤滑油在機內到處飛濺，如果加油量過多，使大量潤滑油積聚在軸封、結合面等處，導致泄漏。
4.安裝和檢修工藝不當
安裝精度不高引起的漏油。減速機在啟動時承受巨大的動載荷,一旦減速機的安裝精度達不到標準要求,將導致減速機底座螺栓松動,從而加劇減速機的振動,使減速機高、低速軸孔處的密封圈磨損加劇,使?jié)櫥土鞒觥Ｍ瑫r(shí)設備檢修時，由于結合面上污物清除不徹底，或密封膠選用不當、密封件方向裝反、不及時更換密封件等，也會引起漏油。
5.油品選擇不當
一般減速機常采用HJ-40、HJ-50號機械潤滑油，也可采用HL-30、HL-20齒輪油及HJ3-28軋鋼機油等潤滑。總之，應根據負荷、轉速、溫度等條件來選用減速機的潤滑油，一味地追求潤滑油黏度越大越好是不對的。
Siemens,LNG3B120L,Breaker VL 1200A T/M 3P 100KA W/Lugs
GUARANTEED BRAND NEW SIEMENS SHND69100AG SHND69100A W/ L,I & G AND LOAD LUGS
Siemens 1200 Amp Main Lug, 277/480 Volt Panelboard - E425
Siemens 1200 Amp Main Lug, 277/480 Volt Panelboard - E427
Siemens 1200 Amp Main Lug 277/480 Volt Panelboard - E670
Siemens 600 Amp Main Lug 277/480 Volt Switchboard - E374
Siemens 800 Amp Main Lug Panelboard - E526
Siemens LMXD63B700 Sentron Series Circuit Breaker 600V 700A 3P (Missing Lugs)
SIEMENS 1200 AMP MAIN LUGS MLO PANEL BOARD P4/S4 NEW 480V/277V ALUM
New SIEMENS ITE HHLXD63B450 450 Amp 3P Pole 600 Volt Circuit Breaker w/LUGS
ITE Siemens Sentron ND63F120 ND 1000 Amp 3 Pole 600 vac Breaker no lug covers
Siemens 800 Amp Main Lug, 120/208 Volt, 3 Phase, Panelboard, # E39
Siemens 800 Amp Main Lug, 3 Phase, 277/480 Volt, CDP-6 Panelboard - E325
Siemens 400 Amp Main Lug, 3 Phase, 277/480 Volt Panelboard - E606
Siemens 400 Amp Main Lug Type F1 277/480 Volt Switchboard - E371
Siemens 800 Amp Main Lug Panelboard, 120/208 Volt # E180
SIEMENS 400 AMP PANEL 240/120 SINGLE PHASE MAIN LUG
Siemens 400 Amp Main Lug 3 Phase, 120/208 Volt Panelboard - E635
Siemens 400 Amp, 120/208 Volt Main Lug 42 Circuit Panelboard - E153
Siemens 250 Amp Main Lug 277/480 Volt Panelboard - E599
Siemens 400 Amp Main Lug, 3 Phase, 120/208 Volt Panelboard - E604
Siemens 400 Amp Main Lug Panelboard - E673
Siemens 400 Amp Main Lug 120/208 Volt, 42 Circuit Panelboard - E519
Siemens 400 Amp Main Lug Panelboard, 3 Phase, 277/480 Volt # E73
Siemens 400 Amp Main Lug, 120/208 Volt Panelboard - E602
SIEMENS HDX3B060 CIRCUIT BREAKER 60 AMP 3 POLE 65KA NO-LUG NEW
BRAND NEW IN BOX ITE SIEMENS EH3-B090 CIRCUIT BREAKER W/ LOAD LUGS
Siemens 400 Amp Main Lug, 277/480 Volt, 42 Circuit Panelboard - E537
SIEMENS 800AMP MAIN LUG P4/S4 PANELBOARD NEW 3PH 4 WIRE 480V/277V ALUMINUM
Siemens 225 Amp Main Lug, 3 Phase, 277/480 Volt Panelboard - E311
Siemens 600 Amp Main Lug 480/277 Volt Panelboard - E90
Siemens CDP7 350 Amp Main Lug 120/208 Volt Panelboard - E648
Siemens 400 Amp Main Lug, 3 Phase, 42 Circuit Panelboard - #291
Siemens JXD63B400 WITH LUGS!!
SIEMENS 600 AMP MAIN LUGS MLO PANEL BOARD P4/S4 NEW 480V/277V ALUM
SIEMENS 600 AMP PANELBOARD W/ 600 AMP MAIN LUG PANEL 208 / 120 3P 4W
Siemens 800 Amp LMXD63B800 600 Volts 3 Pole Missing Lug Cover Extensions
Siemens 250 Amp Main Lug 277/480 Volt, 42 Circuit Panelboard - E152
Siemens Circuit Breaker Lug (Box of 490)
Siemens 125 Amp Main Lug, 3 Phase, 277/480 Volt Panelboard - E349
Siemens 225 Amp, 277/480 Volt, Main Lug 3 Phase Panelboard - E84
Siemens 125 Amp Main Lug, 3 Phase, 120/208 Volt Panelboard - E441
Siemens 250 Amp Main Lug, 3 Phase, 120/208 Panelboard - E378
Siemens Panelboard 250 Main Lug Amps S1C42ML250ABF,
Enlarge
Siemens Panelboard 250 Main Lug Amps S1C42ML250ABF
Siemens 250 Amp Main Lug 120/208 Volt 3 Phase Panelboard - E41
Siemens 250 Amp Main Lug, 277/480 Volt, 3 Phase Panelboards - E533
Siemens Type S3 225 Amp Main Lug 3 Phase, 120/208 Volt Panelboard - E572
Siemens 250 Amp Main Lug 3 Phase 120/208 Volt Panelboard - E244
Siemens 250 Amp Main Lug Panelboard, 3 Phase, 120/240 Volt, Feed Through # E254
Siemens 125 Amp Main Lug 277/480 Volt 30 Circuit Panelboard - E658
Siemens 225 Amp Main Lug 3 Phase, 120/208 Volt, 42 Circuit Panelboard - E568
GUARANTEED BRAND NEW SIEMENS FXD63B225 W/ LOAD LUGS
Siemens Panelboard 125 Main Lug Amps S1C42ML125ATF...
Siemens Panelboard 125 Main Lug Amps S1C42ML125ABF,.,
Siemens Panelboard 125 Main Lug Amps S1C42ML125ATF../
Siemens Panelboard 125 Main Lug Amps S1C42ML125ATF
Siemens 250 Amp Main Lug 120/208 Volt Panelboard w/Feed Thru Lugs - E598
Siemens Panelboard 125 Main Lug Amps S1C42ML125ATF
Siemens Panelboard 125 Main Lug Amps S1C42ML125ATF
Siemens Panelboard 125 Main Lug Amps S1C42ML125ATF
Siemens Panelboard 125 Main Lug Amps S1C42ML125ATF
I-T-E FJ3B225 225 Amp Breaker w Top and Bottom Lugs FJ Siemens ITE Gould 225A A
Siemens 125 Amp Main Lug 3 Phase, 120/208 Volt Panelboard - E595
Siemens Type 51, 125 Amp Main Lug, 42 Circuit Panelboard 120/208 Volt - E195
ITE Siemens FJ3-B200 Circuit Breaker FJ3B200 200 amp Missing 1 Set Of Lugs
SIEMENS G1224ML3125CU MAIN LUG LOAD CENTER 125A NEMA TYPE 1 (INDOOR) 3PH *NIB*
ITE Siemens Circuit Breaker 3 Pole 600 Volts Issue KH-111 Missing 3 Lugs
Siemens Panelboard 125 Main Lug Amps S1C30ML125ATF..
Siemens Panelboard 125 Main Lug Amps S1C30ML125ATF..,.
Siemens 100 Amp Main Lug Panelboard 42 Circuit, 120/208 Volt - E225
SIEMENS Circuit Breaker Lug Kit 3/pk 3TA4NG500 NewInBox
SIEMENS 3TA2N8750 LUG KIT FOR NXD63B100 NXD63B120 ND63
SIEMENS LXD63B600 SHUNT TRIP SENTRON SERIES BREAKER 600AMP 600V RATED WITH LUGS
Siemens G2030L1150 150A Electrical Main Lug Load Center
SIEMENS 250 AMP MAIN LUG ELECTRICAL PANEL 208Y/120 VAC 30 CIRCUIT
SIEMENS / ITE ED43B125L NEW CIRCUIT BREAKER LOAD LUG 3 POLE 125 AMP 240/480Y VAC
SIEMENS 400 AMP JXD23B400 CIRCUIT BREAKER DAMAGE NO THREADS ON LUG TRIPS GOOD
Siemens 100 Amp Main Lug 3 Phase 277/480 Volt Panelboard - E655
Siemens 3TA3NG750 3 pole lug kit for NG breaker
Siemens Circuit Breaker 60A/3-P/Bolt-on/with lugs HEB3B060 NIB
Siemens G4242ML3200CU 200 Amp Main Lug Load Center - E155
Siemens 150 Amp Main Lug Breaker Panel
Siemens 125 Amp Main Lug Breaker Panel 3R
Siemens Circuit Breaker 60A/3-P/Bolt-on/without lugs HEB3BO60
SIEMENS / ITE ED43B070L NEW CIRCUIT BREAKER LOAD LUGS 3 POLE 70 AMP 240/480Y VAC
SIEMENS / ITE ED43B080L NEW CIRCUIT BREAKER LOAD LUGS 3 POLE 80 AMP 240/480Y VAC
SIEMENS / ITE ED43B100L NEW CIRCUIT BREAKER LOAD LUG 3 POLE 100 AMP 240/480Y VAC
SIEMENS 2NLK1 NEUTRAL LUG KIT $159.99
BRAND NEW!!!! SIEMENS W0816ML1125CU 125AMP OUTDOOR MAIN LUG BREAKER PANEL BP-105
Siemens 250 Amp Main Lug Panel 30 circuits 120/240v 1ph 3wire bl feed
Siemens HHED62B100 Sentron Series Circuit Breaker 600V 100A 2P (No Lugs)
New Siemens 2NLK1 200% Neutral Lug Kit
SIEMENS 3TA2LG600LN BREAKER, ALUMINUM LUG KIT NEW
SIEMENS / ITE ED43B015L NEW CIRCUIT BREAKER LOAD LUGS 3 POLE 15 AMP 240/480Y VAC
SIEMENS / ITE ED43B020L NEW CIRCUIT BREAKER LOAD LUGS 3 POLE 20 AMP 240/480Y VAC
SIEMENS / ITE ED43B030L NEW CIRCUIT BREAKER LOAD LUGS 3 POLE 30 AMP 240/480Y VAC
SIEMENS / ITE ED43B040L NEW CIRCUIT BREAKER LOAD LUGS 3 POLE 40 AMP 240/480Y VAC
SIEMENS / ITE ED43B050L NEW CIRCUIT BREAKER LOAD LUGS 3 POLE 50 AMP 240/480Y VAC
SIEMENS / ITE ED43B060L NEW CIRCUIT BREAKER LOAD LUGS 3 POLE 60 AMP 240/480Y VAC
Siemens FXD63B150L Circuit Breaker, 150 Amp, Lugs
SIEMENS G2424L1125 MAIN LUG LOAD CENTER, 125A, 24 1" SPACES, NEW IN BOX
SIEMENS MAIN LUG LOADCENTRE EQ412100 *NEW*
Siemens 125 Amp Main Lug, 1 Phase, 120/240 Volt Load Center E482
Siemens 125 Amp Main Lug Breaker Panel
SIEMENS CIRCUIT BREAKER 225AMPS 3 POLE , TRIPS GOOD; MISSING LUG
SIEMENS MQJ3200 CIRCUIT BREAKER (200 AMP) WITH LUGS
SIEMENS G404OB1200CU MAIN LUG LOAD CENTER, 200A, 3 WIRE, 40CIRCUITS, NEW IN BOX
DS468GK,Siemens Ground Lug Kit 400-600A New in box
SIEMENS 3TA2LG600LD ALUMINUM LUG BREAKER LG LUGS KIT OF 3 POWER TAP CUAL NEW
Siemens TA4H500 4-Conductor MCCB Lug Kit Assy. New
SIEMENS / ITE ED42B030 NEW CIRCUIT BREAKER LOAD LUGS 2 POLE 30 AMP 240/480Y VAC
ED43B020L, Siemens Molded case Circuit Breakers 20AMP 3POLE 480V with lugs
Siemens TA3K500 Lug Kit- Lot of 3 NEW
SIEMENS 150 AMPS W2030L150CU MAIN LUG LOAD CENTER, NIB
SIEMENS NEG3B11OL CIRCUIT BREAKER 110AMP 3-POLE WITH LUGS 480V NIB
SIEMENS 125A INDOOR MAIN LUG 16 SPACES 24 CIRCUITS G1624L1125 BP-111
1 NIB SIEMENS FBT600F THREE POLE LUG PLATE ASSEMBLY WITH COVER
ED23B030, Siemens Circuit Breaker 30AMP 3POLE 240VAC 10KAIC with lugs
SIEMENS 200 AMPS MC060L1200R MAIN LUG LOAD CENTER, NIB(BD)
SIEMENS 150 A. G3030B1150CP MAIN LUG LOAD CENTER, NIB
12 PCS SIEMENS MAIN LUG LOAD CENTER WN2060 NIB
Siemens ED43B030 CIRCUIT BREAKER 30AMP 3POLE 480VAC 18KAIC W/LUG
Siemens Circuit Breaker Lug in Plastic Housing (Box of 75)
Siemens Circuit Breaker Lug in Plastic Housing (Box of 78)
1 NIB SIEMENS TLK35Q TRANS LUG KIT
Siemens 125A 20 circuit Main Lug Load Center G2020L1125
LK3225 , Siemens Lug Kit 3Pole, Sun Feed 225AMP, New in box lot of 2
Siemens CCL600 Compression Lug Kit 600V 600A
SIEMENS G2442L3150CU MAIN LUG LOAD CENTER, 150A, 24 1" SPACES, NEW IN BOX
SIEMENS 125 AMPS G2424L1125 MAIN LUG LOAD CENTER, NIB(BD)
Siemens Main Lug Load Center 125a 125 amp W0204ML1125CU
SIEMENS G2424L1125 MAIN LUG LOAD CENTER, 125A, 3 WIRE, 24CIRCUITS, NEW IN BOX
SIEMENS, G2424L1125, 125 AMP MAIN LUG LOAD CENTER, NEW IN BOX
Siemens W0204ML1125CU Main Lug Load Center 125 Amp New
ITE Siemens TA3K500 Circuit Breaker Lug - New, No Box
SIEMENS G2020L1125CU MAIN LUG LOAD CENTER, 125A, NEW IN BOX
SIEMENS G2424L1125 MAIN LUG LOAD CENTER, 125A, NEW IN BOX
SIEMENS G3042L3200CU MAIN LUG LOAD CENTER, 200A, NEW IN BOX
Siemens Main Sub Feed Lug Kit New in Box MLKA3
SIEMENS FBT250 LUG PLATE ASSEM. 3-POLE W/COVER - FREE SHIPPING
SIEMENS ED43B070 CIRCUIT BREAKER LUGS BOTTOM END *XLNT*
SIEMENS Feed Thru Lugs Main S1 & S2 Panelboard Kit MLKA1 MLKA3 MLKC1 MLKC3 NEW
Siemens, 91D81755012, ACC,3RW34 LUG KIT
SIEMENS 125 A. W3040L1125CU MAIN LUG LOAD CENTER NO BREAKER, NIB
ITE SIEMENS Lugs & Switch for GF 324 364 base 3P 200A
DS100GK,Siemens Ground Lug Kit 30-100A Lot of 10
LOT (3) SIEMENS COPPER TC2-J6500 TERMINAL LUGS
Siemens Main Lug load Center 125A E0408ML1125SU 1 Phase, 3 Wire, 120/240V
SIEMENS 3TA2JG250 *3 PER KIT* VL ALUMINUM LUG 3/0-250 KCMIL NEW
Siemens EF3A025 25 Amp Breaker w Top and Bottom Lugs EF-ETI ITE Gould 25A A
NEW IN BOX SIEMENS TA2N750 MCCB LUG KIT ASSEMBLY
SIEMENS RS5786 ITE ACCESSORY REAR CONNECTING STRAP LUG WITH CIRCUIT 41512
SIEMENS TA2N750 MCCB LUG KIT ASSEMBLY NIB
NEW Cutler Hammer 3 Pole 3BRS225/SIEMENS LK3225 225A Lug Block ZJ-21
SIEMENS SPLIT INSP NEUTRAL LUG KIT (CNLK18) NEW IN BOX
SIEMENS HED43B060 CIRCUIT BREAKER 3 POLE LUG TO LUG 60A
Siemens Panel lugs Qty (6) NTO $39.00
SIEMENS / ITE ED41B020 NEW CIRCUIT BREAKER LOAD LUGS 1 POLE 20 AMP 277 VAC
SIEMENS / ITE ED41B030 NEW CIRCUIT BREAKER LOAD LUGS 1 POLE 30 AMP 277 VAC
SIEMENS TA3K500 MCCB LUG KIT ASSEMBLY BREAKER LMD-NDAI/CU LUG 1,2,3,W 500 NEW
SIEMENS 3TA1JG750 ALUMINUM LUG KIT, 3 PIECE NEW
TE SIEMENS TA2-J6500 USPP TA2J6500 CIRCUIT BREAKER LUG KIT FOR JD FRAME BREAKERS
*NEW* SIEMENS 3RT1955-4G Wire Lug Kit
Siemens ED63A030 30 Amp Breaker Top and Bottom Lugs ED6-ETI ITE Gould 30A A
Siemens ED41B020 BREAKER ED 1P 20A 277VAC 22KA LD LUG
SIEMENS TA2JG250 *MISSING BOLT* BREAKER LUG WIRING RELAY NEW*
ITE SIEMENS RS5786 REAR STUD CONNECTOR LUG SHORT 100A AMP CIRCUIT BREAKER ASSY
SIEMENS TA2JG250, CIRCUIT BREAKER LUG/WIRING RELAY, 400 AMP, NEW*
Siemens ED63A030 30 Amp Breaker Bottom Lugs Faded Label ED6-ETI ITE Gould 30A A
Siemens ED63A005 5 Amp Breaker Top and Bottom Lugs ED6-ETI ITE Gould 5A A 5Amp
ITE Siemens Type ET100 Circuit Breaker 3 Pole 600 VAC Missing 6 Lugs
SIEMENS HEB1B020B CIRCUIT BREAKER 20AMP 1-POLE BOLT-ON w/ LUGS 240V TRIPS GOOD
Siemens CCQ225 Compression Lug 600V 225A
Siemens CCF250 Compression Lug 600V 250A
Siemens,TA6ED06,Breaker ED Distrib. Lugs 6W #14CU
CMC LI-750 LAY-IN PEDESTAL LUG 750MCM-250MCM REMOVED FROM SIEMENS METER CENTER
Siemens 60 Amp Indoor Load Center Main Lug E0204ML1060S
Siemens CCE125 Compression Lug 600V 125A
Siemens Main lug load center
SIEMENS HG61234 GROUND LUG KIT ***NIB***
SIEMENS 3VU9135-1BB01, LINE SIDE FEEDER LUG, 63 AMP, NEW*
I-T-E SIEMENS TA2-K500 LUG KIT ASSEMBLY FOR MD6 FRAME
Siemens TA1E6125 Lug Kit
SIEMENS FBT166-1 10mm BUSBAR WIRE TERMINALS FOR 16-6 AWG - 3 LUGS/BAG
Siemens TA1E6125 Lug Kit
Siemens 3RV1915-5A Line Side Feeder Lug
SIEMENS Grounding Lug Kit KTGL ktgl NEW IN SEALED BAG
Siemens 3VU9135-1BB00 lineside feeder lug
SIEMENS CIRCUIT BREAKER LUG KIT LN1-E100
Siemens LN1E100 Lug Kit
I T E SIEMENS Lug Bonding Kit BK1 New Old Stock GREEN
TAIQ300 NEW SIEMENS LUG KIT
SIEMENS / ITE TC1Q1 ACCESSORY LUG KIT PKG OF 6 ITEMS
SIEMENS 3RV1915-6A Line Side Feeder Lug ! NEW ! No Box
NEW FACTORY SEALED ITE SIEMENS CIRCUIT BREAKER LUG KIT LN1-E100 30-100 A
1 NIB SIEMENS LN1-E100 LN1E100 CIRCUIT BREAKER LUG
SIEMENS LN1-E100 lug for E-frame breakers NIB
