A16B-1211-0946現貨 in stock! 歡迎來電咨詢~！！

A16B-1211-0946,

A16B-1211-0946

　　在現代制藥工業的生產過程中，不可避免地要使用大量的化學與生物制劑，這帶來的一個結果是在生產的每個步驟都會排放出成分復雜的尾氣，以揮發性有機化合物(VOC)居多。如何處理含VOC的尾氣，成為企業面臨的一大環保難題。國內目前主要采用熱氧化法的處理方式，即蓄熱式熱力焚化爐(英文名為“Regenerative Thermal Oxidizer”，簡稱為“RTO”)
　　二、RTO工作原理
　　把有機廢氣加熱到760攝氏度以上，使廢氣中的VOC在氧化分解成二氧化碳和水。廢氣首先通過蓄熱體加熱到接近熱氧化溫度，而后進入燃燒室進行熱氧化，氧化后的氣體溫度升高，有機物基本上轉化成二氧化碳和水。凈化后的氣體，經過另一蓄熱體，溫度下降，達到排放標準后排放。不同蓄熱體之間通過切換閥，隨時間進行轉換，分別進行吸熱和放熱。氧化產生的高溫氣體流經特制的陶瓷蓄熱體，使陶瓷體升溫而“蓄熱”，此“蓄熱”用于預熱后續進入的有機廢氣，從而節省廢氣升溫的燃料消耗。陶瓷蓄熱體應分成兩個(含兩個)以上的區或室，每個蓄熱室依次經歷蓄熱-放熱-清掃等程序，周而復始，連續工作。蓄熱室“放熱”后應立即通過反吹風機對該蓄熱室進行清掃(以保證VOC去除率在95%以上)，只有待清掃完成后才能進入“蓄熱”程序。RTO設備的工作流程見下圖：
　三、控制要求和方法
　　3.1. 燃燒器控制
　　氧化室安裝一個帶比例調節的天然氣燃燒器。燃燒器的供熱量是用氧化室溫度，經過PID調節器自動調節，當燃燒器運行時，燃燒器PID的SP外給定值(TE05_AM)等于SP外給定值+升溫速率設定值/120。按照升溫曲線進行升溫。否則，SP外給定值等于氧化室溫度。如果SP外給定值超過TE05_S10(氧化室溫度--理想控制溫度設定)，那么TE05_S10直接賦值給TE05_AM(SP外給定值)，進行溫度限制。此外，燃燒系統還帶有熄火保護、超溫報警和超溫自動停燃燒器等功能。
3.2.進氣、出氣、清掃流程的切換
　　該設備有三個蓄熱室，一個公共氧化室，有機廢氣通過鼓風機送入蓄熱室1，吸熱后進入氧化室，蓄熱室1因放熱而降溫，燃燒升溫后的氣體進入蓄熱室2，通過熱交換把熱量蓄存在蓄熱室2的陶瓷蓄熱體中，處理后的氣體經后續處理合格后煙囪排空。同時蓄熱室3空間中殘留未處理的VOC廢氣被反吹風機吹回氧化室焚化處理。經過一段時間(約2分鐘(可設定))后，氣流改變方向從蓄熱室2進入氧化室，通過蓄熱室2吸收熱量升溫后，在氧化室內高溫焚化，最后經蓄熱室3熱交換后排放，同時蓄熱室1處于清掃狀態，經過一段時間(約2分鐘(可設定))后，氣流再次改變方向，不斷的交替循環，保證氧化室溫度在800℃以上，以此保證高的去除率和換熱效率。程序如下圖：

上億庫存，國內外近千個倉庫，公司部分產品型號如下，歡迎聯系哦~！

294E-FD2P5Z-G3 Variable Frequency Drive

PFP-100N 導軌 1米

1492-SPM1D160 MCB Supplementary Protector 16 A

總線插頭 6ES7972-0BA41-0XA0 RS485 總線插頭， 12MBd 35? ，不帶編程接口

軟啟動器 3RW44452BC46

TIA 博途 WinCC 選件 6AV2107-2LH00-0BD0 SIMATIC WinCC DataMonitor for Runtime Professional Powerpack 10 -> 25 Clients

150-SCMR SMC-50 CONTROL MODULE 24 VDC

1738-8CFGDLXM12 ArmorPoint 8 Point Combination Module

1783-US4T1H Stratix 2000 4+1 unmanaged port switch

193-EXP-AIO-31 E300 Analog Expansion Module

20-750-MNT3-F10 PF755 FR10,IP00,FLOOR MOUNTING KIT

2090-CPWM7DF-16AA90 MP-Series 90m Servo Power Cable

20AB-DB1-A PowerFlex 70 Resistor Kit

GA647IFESGRN00150 GCA iFIX Optn: ESig & ERec 150 I/O Run

GP-3102NT GagePort Combo NT 2-port input

IC5105KAX0001 Panel C IPC 15in Unbundled WXP

IC647HSTCC150KM Calculation Collector for Historian - Standard Server 150000 Points (M4 Key)

IC647SYM001 Scheduler Yeast Manufacturing

IC693MDL752LT 5/12/24 Vdc (TTL) Output, Neg Logic, (32 points) (LT)

IC756LDV000J-98 DV Development - Intel/Linux RedHat Op Sys, Japanese, Version 9.8

Pico Controllers 1760-DUB GFX DISPLAY WITH BUTTONS

PLC-5/1771 System 1771-OC 48V DC OUTPUT MODULE, 8 OUTPUTS

Distributed I/O 1791R-8V8P RIO 24VDC COMPACTBLK, 8 IN SOURCE 8 OUT SINK, BASE

Communications 1786-CTK CNET RG6 TOOLKIT

Operator Interface 2706-PENETK ETHERNET/IP COMMUNICATION MODULE 2706-P7X & P9X

Support 9701-VWSCRAR SUPT REINSTATEMENT CONTRACT FOR 9701VWSCRAENE

Support 9324-RL0100DES SUPT RENEWAL CONTRACT FOR 9324RL0100DE

EtherNet/IP Products 2711P-K12C4B2 PV PLUS 1250, KEYPAD, RIO/DH, AC PS, EXT MEM

RSI Software Products 9301-2SE340KOU2R RSVIEW32 RUNTIME 300-32K UPGRADE OUT-SUPT (KO)

RSI Software Products 9356-PRO2350U5 UPGRADE: IN-SUPT: RSSQL PROF.150 TO PROF.5000 TAG

Motion Control F-4030-Q-H04AN MOTOR,F-,NEMA 56C W/24V BRAKE,30 IN LB CONT.

4261A-6-N4 7 SEG PANEL DISP. 6 DIGIT. ASCII/SERIAL INTERFACE. QUICK CONN W/PROTOCOL CONV. NEMA 4

IC200ACC202 EXPANSION CONNECTOR QTY 2

IC693CSE323 Series 90-30 10-Slot State Logic CPU in base Model 323

TGT-AI0V-8-0 Target Analog Module 4 Inputs, 4 Outputs

VDNC-SF VisualDNC ShopFloor includes VisualDNC Edit and VisualDocs Basic ShopF loor.

20BD014A3AYNANC1 PowerFlex 700 AC Drive 14 A at 10 Hp 20B

20G11BE760AN0NNNNN PowerFlex 755 AC Packaged Drive

22C-B075A103 PowerFlex 400- 18.5 kW (25 HP) AC Drive

140XBE10000C Quantum 背板擴展模塊, CC

285-BRC24-M3 Source Brake Cordset Cable, 3m

H3Y-2 DC24 1S 5S二開/二閉

1492-SPM1D080 MCB Supplementary Protector 8 A

通用型變頻器 6SE6 440-2UD22-2BA1 2.2 KW,149 x 202 x 172

電機啟動器 3VU13403NH00

150-C43FBD Encl. SMC-3 43 A Smart Motor Controller

1609-PSB1 1609 UPS Accessory

1771-DBMEM1 1771 Memory Module

193-EC2DD E3 Plus 9-45 A Overload Relay

198-MS17 IEC Enclosure Accessory

2090-CPBM7E7-16AF07 MP-Series 7m Length Pwr and Brake Cable

2094-AL25S Kinetix Line Interface Module

CQPK3D200L2P 6 inch Monochrome/ TCP Label/ 24VDC/ UL/ cUL/ CE/ UL1604

GFK-0450 Genius PowerTRAC Block User's Manual

IC200UEX626 6 channel Analog expansion. (4) Analog inputs & (2) Analog Outputs, 2 4VDC Power Supply (*includes IC200CBL501)

IC647APC999 PA Production Client - UNL

IC647PFL050 Proficy Process Systems Standard Edition 500 I/O with iFIX

IC693CHS397RR Base, CPU, 5 Slots, Use With CPU331

IC754PCMCIA001 PCMCIA Interface Adaptor

KIT-GFS-365-CN Proficy HMI_SCADA CIMP & iFIX Wkshp Kit

SLC/1746 System D1747-RM001CENP SLC 500 INSTRUCTION SET REFERENCE MANUAL

Distributed I/O 1734D-IB16S 24 VDC 16 IN, DNET COMMS, SPRING

Application-specific products 1803-EEM01 EEM, 8 ANALOG, 4 TO 20 MA

Operator Interface 2711-T10G1 PV1000 GRAYSCALE TOUCH, RIO & RS232 PRINT

Support 9301-2SE3500ITR SUPT REINSTATEMENT CONTRACT FOR 93012SE3500IT

Support 9381-PA500KENS SUPPORT RENEWAL CONTRACT FOR 9381PA500KEN

DeviceNet Products 1790D-T8BV8V DNET LDX 24VDC,8 UNIV IN/8 SINK OUT BASE, TERM BLK

RSI Software Products 9301-2SE330ESU2R RSVIEW32 RUNTIME 150-1500 UPGRADE OUT-SUPT (ES)

RSI Software Products 9358-PBEBNT60ENE RSBATCH NT & EPROCEDURE BNDLE PROCESLGIX 60 UNITS

Motion Control MPL-B580J-MK22AA MOTOR,SERVO,34.0NM,3800RPM,MULTI,460V,32MM SHAFT

Motion Control 2090-UXLF-370 AC LINE FILTER,ULTRA,70 AMPS,3 PHASE

GQSI31200C2P QUICKSTART KIT 10.5" TFT GE LABEL

IC646NGW000 WebGateway (Unlimited Users)

MTR-3T55-H-R-0-M-0 MTR-Series Servo Motor, Resolver, Metric

ST-1324 STXi input module 4 points, Negative Logic, 48VDC

20BC085A0AYNACC0 PowerFlex 700 AC Drive 85 A 45 kW 20B

20F11RD011AA0NNNNN PowerFlex 753 AC Packaged Drive

22A-A2P3N114 PowerFlex 4- 0.4 kW (0.5 HP) AC Drive

140CHS41010 Quantum Quantum經濟性熱備包,140CPU11302

283D-FB19Z-ND-R-3 Cntl Mod. Smart Motor Controller

C200H-TS001 溫度檢測,熱點偶輸入（K,J） 4路

1492-RCDA4B40 Residual Current Device 40 A

同步光纜 6ES7960-1AA04-5AA0 同步光纜 1m

變送器 3RS10 42-1GD70

1497-G-M5-0-N Control Circuit Transformer

1606-XLE120EE Power Supply XLE 120 W Power Supply

1762-RPLDIN2 MicroLogix Replacement Part

188-K3D100-N Miniature Circuit Breaker 10 A

194L-HE4A-175 194L Control and Load Switch Actuator

2090-CPBM7DF-08AA05 MP-Series 5m Power and Brake Cable

2090-XXNPMF-14S07 Kinetix Drives 7m Standard Cable

BC647TPR700 CIMPLICITY HMI ProServer 700 I/O Runtime System with Proficy GlobalCare

GC647PRTSQL GlobalCare Complete - Proficy Portal SQL Server Connector Ver 3.0

IC200MDL750 Output 12/24VDC POS LOGIC 0.5A per point (2 groups of 16) 32 points

IC646PMB000 PMCS DDE Modbus Mini Server

IC647MT1M MT1:Met One

IC684TROLI602 CIMPLICITY HMI Plant Edition Online Course -Module 2

IC697VAL301 Replacement is Embedded VME-4132-010000 Contact GE IP Embedded for details.

IC800SSI228RP2 28 amp 230 VAC Profibus S2K servo controller for MTR series motors

SLC/1746 System 1747-L552 SLC 5/05 CONTROLLER

Industrial Computers 6181P-12TP2KH VERSAVIEW INTEGRATED DISPLAY COMPUTER 12-INCH

Application-specific products 9358-PBBK03ENE RSBIZWARE BATCH FOR PLX BACK-UP KEY 03 UNITS

Operator Interface 2711-K5A10L2 PV550 MONOCHROME KEY, DNET & RS232 PRINT

Support 9306-4EXP01U1R UPGRADE: OUT-SUPT: DRIVEEXPLORER VER 1.XX TO 2.XX

Support 9393-RSTCLXR SUPT REINSTATEMENT CONTRACT FOR 9393RSTCLX, PCLX

ControlNet Products 2711-K10G15 PV1000 GRAYSCALE KEY, CNET & RS232 PRINT

RSI Software Products 9301-2SE2500PTU4 RSVIEW32 WORKS 150-100K UPGRADE IN-SUPT (PT)

RSI Software Products 9358-BEPB30U1 UPGRADE: IN-SUPT: RSBW BATCH & EPROCEDURE 3 TO 30

Motion Control MPL-A4540C-SJ24AA MOTOR,SERVO,10.2 NM,1500RPM,SINGL,230V,BRK,13KG

Motion Control 2090-XXNFY-S02 CABLE,NON-FLEX,MOTOR FEEDBACK,Y,2M

CBL-T7-MP-30 Power Cable, MTR-3T1x & MTR-3T2x Series Servo Motors, 30 Ft.

IC641PCC124 Logic Engine (runtime) w/o GUI - 512 Points

IC800SSD228RS1 28A, 230V, S2K Servo Drive for MTR Series Motors

PR-PAT-FS01 Proficy PAT - Driver For Foss Near Infrared Systems Near-Ir Spectrometers

20BB-DB1-2 PowerFlex 700 Resistor Kit

20DD820A0ENNBNANE PowerFlex 700S AC Drive 820 A 700 Hp 20D

20YF1K0A0ANNANA0 PowerFlex 700 AFE Active Front End

2711P-CBL-EX04 PanelView Plus EtherNet Crossover Cable

280-PWRM35C-M30 ArmorConnect 3-PH Power Media trnk cable

CPM2A-20CDR-A 20點主機 AC100-220V 12點入8點繼電器輸出 自帶RS232C口

1492-MS5X12V11-20 Connection Products

1495-N62 Protective Fuse Cover

行程開關 3SE53120SE12

運行版軟件 6AV2107-0DB04-0AA0 SIMATIC WinCC Client for Runtime 專業版 V14

1585J-M4TBJM-60 RJ45 Ethernet Media

1756-OF8IK ControlLogix 8 Point Analog Output Isola

188-K1C080 Miniature Circuit Breaker 8 A

194E-HE4N-175 194E Load Switch Actuator

2090-CFBM7DF-CEAA12 MP-Series 12m Servo Feedback Cable

2090-UXLF-132 Ultra Series 32A AC Line Filter

BC646PEW110 OP EWS Development Software 700 I/O w/GC

GC647IFCLNTCRO001 GCC iFIX iClient Read Only 5 PK Keyless Runtime Version

IC200ALG320 Analog output 12 bit current 4 channel

IC646IFCLNTCRO050M iFIX iClient Read Only 50 PK Keyless (M4 Part)

IC647IFPRDV00150M iFIX Profsnl SCADA 150 I/O Development (M4 Part)

IC660SLA023 Red Safety Label Kit for IC660BBA023 Genius Blocks

IC697BEM764RR DLAN Interface for VME

IC800BPK012 BSVU-12 12 amp Beta series amplifier kit

ControlLogix/1756 System 1756-L62 LOGIX5562 PROCESSOR WITH 4MBYTE MEMORY

Industrial Computers 6182H-7BRH6B VVCE 700, KEY/TOUCH, STD MEM, RIO/DH, AC

Process Control 9358-PB30ENE RSBIZWARE BATCH FOR PROCESSLOGIX 30 UNITS

Operator Interface 2711P-K15C4B2 PV PLUS 1500, KEYPAD, ENET, AC PS, EXT MEM

Support 9352-WABGWR SUPT REINSTATEMENT CONTRACT FOR 9352WABGW

Support 9308-RSFBENU2 UPGRADE RSFIELDBUS CONFIG SW 64 TO 1024 FB

Support F5250-LP3 FIRMWARE UPGRADE FOR 5250-LP3 PLC5250 PROCESSOR MO

RSI Software Products 9301-2SE2353ESE RSVIEW32 WORKS 5K WITH RSLINX (SPANISH)

RSI Software Products 9351-VS INTERCHANGE FOR OPENVMS

RSI Software Products 9399-WINIGIT INSTAL'ION GUIDE FOR WINDOWS-BASED PROD.(ITALIAN)

Motion Control 2090-CDNPBMP-8S05 CABLE,460V,NON-FLEX,MOTOR POWER,MP,8 GAUGE,5M

BC646MSP001 Logic Developer - State Professional w/1Yr of SAFE

IC300TIU101 Operator Control Station, Two serial ports, (1) RS-232 and (1) RS-485/RS-232 port, (1) CAN port. No SmartStack or Control Support

IC754VSI06MTD 6" Monochrome Quickpanel View Intermediate, Touch, 24VDC

MTR-3T66-H-R-0-M-0RR Servo Motor Metric

20AD011A3AYNACC0 PowerFlex 70 AC Drive 11 A at 7.5 Hp 20A

20DC037A3NYNANDNL PowerFlex 700S AC Drive 20D

20G1ANC302JA0NNNNN PowerFlex 755 AC Packaged Drive

25C-A2P5N104 PowerFlex 527 0.4kW (0.5Hp) AC Drive

280-M35F-M3 ArmorConnect M35 Female Receptacle

FR-F740-37K 53.3KVA 70A 37KW 3相AC380V/50Hz/60Hz

1492-LG6T IEC Term Blck 8.1x90x38mm Spr Clp

1494G-CF3N-420 NEMA 1494G Enclosed Disconnect

軟啟動器 3RW44366BC36

ET 200SP 6ES7132-6BD20-0DA0 DO 4x24VDC/2A 高速型，基座單元類型 A0

1585D-E4UBDE-5 1585D Ethernet Media Patchcord

1756-A10 ControlLogix 10 Slots Chassis

1794-IF2XOF2I Flex 2 Input 2 Output Analog Module

194E-AA63EX-PE-TN 194E Load switch

2080-LC30-48QWB Micro830 48 I/O Controller

2090-CSWM1DF-18AA10 Kinetix Cable Single DSL 2090-Series

20AC3P5A3NYNAEC0 PowerFlex 70 AC Drive 20A

GC646MRA000 Proficy GlobalCare Complete for View Runtime 8,000 I/O

HE693RTU900 Single Port RTU Slave Interface Module w/RS-232 and RS-485

IC610MDL110RR High Speed Counter Module

IC647HSTSS100KM-35 Historian v3.5 Standard Server 100000 Points (M4 Key)

IC660BBD024 Block 12/24Vdc Source I/O 32 Circuits

IC694TBB132 Box Style High Density Terminal Block with extended depth for large wires - 36 Connections

IC756WDN009K-22 DV Development Sys VB, Java, C++, C, Korean, Version 2.2

CompactLogix System 1769-L35CR COMPACTLOGIX REDUNDANT CONTROLNET

PLC-5/1771 System 1771-P7K CONFORMALLY COATED, POWER SUPPLY, 16A, 120/220V AC

Distributed I/O 1798-BP2 FLEXARMOR 2 SLOT BASE PLATE

Operator Interface 2711P-K6C20A PV PLUS 600 COLOR, KEYPAD, ETHERNET, AC PS

Support 9323-PI300S SUPT RENEWAL CONTRACT FOR 9323PI300

Support 9358-PBA10R SUPT REINSTATEMENT CONTRACT FOR 9358PBA10ENE

Support F1775-KA FIRMWARE UPGRADE FOR 1775-KA PLC3 PROCESSOR MODULE

RSI Software Products 9324-RLD700NXFRE RSLOGIX 5000 PRO EDITION, FRENCH

RSI Software Products 9305-RSVADSDEE RSVIEW32 ACTIVE DISPLAY SERVER (GERMAN)

RSI Software Products 9308-RSFB256ENE RSFIELDBUS 256 FB BASE CONFIG SW

Motion Control 2094-PR4 POWER RAIL,230V OR 460V , 4 AXIS

A06B-6073-K250 Fuse, Beta & I/O Link Series Amplifier Control Power

IC200UEX011-24 Qty of 24, 14 point expansion. (8) 24VDC In, (6) Relay Out, 120V/240AC Power Supply (includes IC200CBL501)

IC752CBT070 Mature, order QuickPanel instead. DataPanel 320T CEG (Color Expansion w/ Genius): 320x240 1/4 VGA Passive Color with 80386SX/40 PC processor. Analog touch screen with text, bitmaps, bar graphs, real time clock. W/ 2Meg and Genius PC/104.

MTR-1N42-H-N-A-E-0RR Stepping Motor Nema42

ZA06B-0143-B075#7008 A12/3000 servo motor with 64k serial encoder

20BD5P0A3AYYAEC1 PowerFlex 700 AC Drive 5 A at 3 Hp 20B

20G14NC140AN0NNNNN PowerFlex 755 AC Packaged Drive

25-PM1-E032 PowerFlex 520 22kW (30Hp) Power Module

OFSCSPBLF Quantum OFS LARGE 200 LIC SUBSCR RENEWAL

FRN15E1S-2J 22KVA 60A 15KW 3相AC220V/50Hz/60Hz

1492-J3-OR 2.5 square mm Standard Terminal Block

1492-SPM3D070 MCB Supplementary Protector 7 A

軟啟動器 3RW40382TB05

SIMATIC HMI 系列面板 6AV2124-2DC01-0AX0 KTP400 精智 4英寸，按鍵+觸摸

150-SF3R SMC-50 Frame D 24V DC Replacement Fan

1738-EP24DC ArmorPoint I/O Extension Power Module

1783-ZMS8T8E2TGP ArmorStratix 5700 18 Port managed switch

193-KB10 0.75-1.0 A IEC Bimetallic Overload Relay

20-750-PBAY-INS-3 POWERFLEX 750 KIT,INSULATOR,3 BAR

2090-CPWM7DF-16AF50 MP-Series 50 m Length Power Cable

20AB042A0AYNANC0 PowerFlex 70 AC Drive 42 A at 15 Hp 20A

GA647IFPLRN00075 GCA iFIX Plus SCADA 75 I/O Run

GP647IFCLNTSRO005 GCP iFIX iClientTS Read Only 10 PK Runtime Version

IC600BF817RR Type B Thermocouple Input Module (8 points)

IC647HSTCC500M Calculation Collector for Historian - Standard Server 500 Points (M4 Key)

IC647TDV150 CIMPLICITY HMI Server 150 I/O Development & Runtime System

IC693MDL931LT Relay Output, 8 Amp Form B/C contacts, Isolated in groups of 4 (LT)

IC756LDV001J-97 DV Development - Intel/Linux RedHat Addt'l User, Japanese, Version 9.7

Pico Controllers 1760-NMF GFX MOUNTING FT; 8 PER PK

PLC-5/1771 System 1771-OP 120V AC PROTECTED OUTPUT MODULE, 4 OUTPUTS

Distributed I/O 1791-32A0 BLOCK I/O, 120V AC, 32 POINT MODULE (32 INPUT)

Communications 1786-TPS CONTROLNET T-TAP/STRAIGHT

Operator Interface 9701-VWSTMJPE RSVIEW STUDIO FOR MACHINE EDITION (JAPANESE)

Support 9701-VWSTPR SUPT REINSTATEMENT CONTRACT FOR 9701VWSTPENE

Support 9324-RL0300ENS SUPT RENEWAL CONTRACT FOR 9324RL0300EN

EtherNet/IP Products 1747-L553P PRO-SET 200 - 5/05 - 64K

RSI Software Products 9301-2SE3500DEU2 RSVIEW32 RUNTIME 1500-100K UPGRADE IN-SUPT (DE)

RSI Software Products 9356-PRO2450U5R UPGRADE: OUT-SUPT: RSSQL PROF.150 TO PROF.32000 TA

Motion Control F-6300-R-H04AA MOTOR/ENCODER/BRAKE

44A728335-004 Test Only - PowerMotion

IC200ALG261 ANALOG INPUT 15 BIT DIFFERENTIAL VOLTAGE 8CH

IC693MDL750 12/24 Vdc Output, Negative Logic (32 Points)

Silver Series 2711-T14C8 PV1400 COLOR TOUCH, DH+ & RS232 PRINT