1794-TB3K現貨 in stock! 歡迎來電咨詢~��！

作為火電廠安全經濟運行主導因素的熱控自動化設備DCS系統，近年來得到了普遍應用，為火電廠機組安全、穩定的運行起到了積極的作用。但是，DCS系統的安全性和可靠性還有待提高，在運行過程中經常會出現這樣或那樣的故障，這些故障的出現，導致了發電機組的非計劃停運，給發電企業造成不應有的損失。
　　1、DCS系統常見的故障
　　隨著工業生產自動化的不斷興起、過程控制要求的日益復雜，一種綜合控制系統――DCS系統應用而生了。由于目前各火電廠對DCS系統的應用水平的限制，系統在運行過程中難免會出現故障。常見的DCS系統故障有：電源系統故障、硬件(模件)故障、系統軟件故障和通信網絡系統故障。
　　1.1電源系統故障
　　電源故障是DCS系統的致命故障，一旦電源出現故障，不僅整個系統會停止運行，而且還會導致機組的跳閘，造成非計劃停運。
　　1.1.1電源系統出現故障的主要原因
　　電源方面的問題比較多，一是備用電源不能自投，雖采用UPS和APS雙路互為備用的供電方式，但在轉換時也會出現瞬間失電，導致機組跳閘;二是保險配置不合理及DPU電源內部故障等造成電源中斷，導致系統運行的停止;三是穩壓電源波動引起保護誤動及接插頭接觸不良導致穩壓電源無輸出;四是有的系統整個機柜通過一路保險供所有輸入信號或一路電源外接負載很大，導致模件的損壞;五是系統電源未采用UPS供電，冗余備用就更無從談起。
　　1.1.2電源系統故障應采取的防范措施
　　要保證DCS系統的安全、穩定，首先要具備合理的電源布置，其次要選用高質量的電源模塊，并要保證較高的冗余率。再次是注意觀察電源的輸出電壓，防止出現波動。第四是對電源實行壽命管理，該更換的時候必須更換，絕對不允許等到電源出現了故障的時候才更換。
　　1.2硬件(模件)故障
　　DCS系統的硬件(模件)卡件可分為處理器模件、I/O模件及通訊模件三大部分，這三大模件的功能各自不同，常見的故障部位為過程通道和人機接口。
　　1.2.1硬件(模件)出現故障的主要原因
　　①過程通道故障也就是I/O卡件故障。引起I/O卡件發生故障的第一方面的原因是卡件因長時間工作而出現老化和損壞，這種工作的發生，一般是隱藏性的，只有參數出現異常，系統才會報警;第二個方面是連接線松動導致部分I/O模件與主機的通信中斷，在這種情況下，系統會馬上做出反應，出現報警;第三個方面是外界強電信號竄入形成干擾而導致通道故障的發生。
　�、谥T如球標和控制操作出現失靈和實效以及操作員站出現死機、鍵盤和打印機出現工作不正常的現象都屬于人機接口故障。
　　球標操作失靈的原因有裝置因長時間工作發生老化或者被浮塵或油膩污染，致使觸點不能實現自行通斷，也或是電纜插頭接觸不良造成與主機的通信斷路。
　　控制操作實效的主要原因是因球標的操作信號不能改變過程通道的狀態，有三種可能：其一可能是過程通道硬件發生故障;其二可能是操作員站所用軟件的缺陷;其三是設備超負荷或者過多地打開窗口，導致不響應。
　　操作員站死機的原因基本與控制操作失效的原因相同。
　　鍵盤工作不正常的原因有：鍵盤組態出現錯誤、接觸不良、連接電纜松動或者在啟動主機時誤動了鍵盤，造成啟動缺失。
　　打印機出現工作不正常的原因：或者是配置不合理，或者是因對打印機實施屏蔽而造成的。

SIEMENS 6SN1146-1AB00-0BA1 6SN1 146-1AB00-0BA1 SIMODRIVE 611 Infeed Module QTY

SIEMENS SIMODRIVE 6SN1145-1AA01-0AA1SINUMETIK 840D NCU-BOX 6FC52476FC5357 6SN

Advantest Teach Pendant Teaching Programmer 0401004AA

ALLEN-BRADLEY 700-P800A-1 RELAY 8NO 120VAC 10AMP XLNT

ABB BAILEY SYMPHONY CONTROLS DIGITAL IMASI23 ANALOG INPUT SLAVE MODULE 88109

AC Tech M3500B AC Drive 60HP 460v/575v WOW

6ES7414-3XJ04-0AB0 Brand , Factory Sealed,

0010-11997 Assy., Heater, TxZ, 200mm SNNF

MODICON MM-PMC3-10S USPP MMPMC310S

ALLEN BRADLEY 150-A97NBDA USPP 150A97NBDA

ALLEN BRADLEY 1326AB-B2E-11 NSPP 1326ABB2E11

GENERAL ELECTRIC 0621L0437-G001 USPP 0621L0437G001

SQUARE D 8536-SGO1-V02S USPP 8536SGO1V02S

SIEMENS 6FX-1127-4AB01 USPP 6FX11274AB01

ALLEN BRADLEY SP-151135 USPP SP151135

Siemens 6ES5 942-7UB11 6ES59427UB11

Siemens Simatic S5 6ES5 242-1AA13 6ES52421AA13

SIEMENS 6ES5-635-0UB12 USPP 6ES56350UB12

Siemens 6ES5 451-7LA12/6ES54517LA12 E-Stand Version 06 FACTORY SEALED

Siemens 3RK1903-1CB00 / 3RK19031CB00

Siemens Eupec IGBT BSM200GA170DN2SE3256

SBI-7126T-S6 876GB SAS Blade Server 2x 2.53GHz Nehalem

Square D ATV66D12N4

SIEMENS AS-INTERFACE MODULE 3RK1402-3CE01-0AA2

WE SHIP SAME AIR-CAP3502I-A-K9 CISCO 1yr

SIEMENS 6SE7 090-0XX84-0AD1 Card

Siemens TP277-6 6AV6643-0AA01-1AX0 Touch Glass

Schneider Modicon Gould AS-S908-110 ASS908110 PLC Remote I/O Processor Module

Schneider Modicon ASBADU214 BRANDCompact Analog Input AS-BADU-214

Schneider Modicon AS-B829-116 NSFP ASB829116

Schneider Modicon AS-E680-904 MODULE ASE680904

Schneider Modicon AS-W907-025 USPP ASW907025

Schneider Modicon AS-E485-904 ASE485904 Executive Cartridge

Schneider PLC Output Module 140DRA84000

SIEMENS 6ES5432-4UA12 SIMATIC S5 DIGITAL INPUT MODULE PLC CARD

Roland VG-99 V-Guitar Multi Effects Processor System with GK-3 Pickup

Siemens Coros Op 15 6AV3515-1EB01

SIEMENS SINUMERIK 840D 6FC5210-0DA00-1AA16FC5203-0AB12-0AA1 MMC-100 HMI

Reliance Remote I/O Communications Module 57C416

SIEMENS Adapter 6SN1161-3AA23-0AA0 (CMI# 1-230-1237A)

SIEMENS 6FC9338-1A8 Simodrive cable measuring adapter

SIEMENS 6FC5110-0DB03-0AA2 | 12mo warranty | Free EU Shipping | Inc UK VAT

AllenBradley2711-T10G1/D2711T10G1Panelview1000

Allen Bradley VersaView 1700P Interface Panel Catalog 6181F-17TPXPH Series D

ABB EHW-250WC-1L Size 5 Welding Isolation Contactor

Advanced Energy 3150073-001 AE RF-10S, RF Generator, 1000W Novellus G19-10071-00

(L18) 1 ALLEN BRADLEY 1785-L40C CONTROL NET PROCESSOR CPU PLC-5/40C L18

LECROY 9112 USPP 9112

ALLEN BRADLEY 1100-AOD93 USPP 1100AOD93

FUJI ELECTRIC FRN7.5G11S-4EN USPP FRN75G11S4EN

FANUC A06B-0632-B011 USPP A06B0632B011

SICK OPTIC ELECTRONIC LUT1-420 USPP LUT1420

RELIANCE ELECTRIC 0-52855 NSFP 052855

SICK OPTIC ELECTRONIC CLV430-6010 NSFP CLV4306010

Siemens 6ES5 464-8MF21 ANALOG INPUT MODULE IN BOX

Siemens 6ES5-942-7UA12 NSPP 6ES59427UA12

SIEMENS 6ES5-431-8MC11 USPP 6ES54318MC11

Siemens 6ES5 700-8MA11

Siemens S5 6ES5 700-8MA11 6ES57008MA11 Base

SIEMENS C73040-A51-C154-02-85 J2 Worldwide

Siemens 6ES5-453-7LA11 PLC

Square D 8010 SFI-510

Nortel Passport 15000 multiservice switch Mac Address interface module NTHR11BA

WS-C6506-E CATALYST 6506 ENHANCED CHASSIS 6 12RU

Siemens 6ES7221-0AA22-0XB0 6ES7 221-0AA22-0XB0 CPU221

Siemens Simatic CPU 221 6ES7211-0BA21-0XB0

Reliance 57C421B

Schneider Modicon GOULD 24VDC INPUT MODULE CAT AS-B827-032

Schneider Modicon AS-B360-001 USPP ASB360001

Schneider Modicon AS-S929-001 USPP ASS929001

Schneider Modicon AS-BADU-214 Analog Input Module ADU-214 In ASBADU214 ADU214

Schneider Modicon AS-B814-108 Output Module Relay NO/NC 5A/30VDC 4A/230VAC 8PT

MODICON AS-B824-016 OUTPUT MODULE ASB824016

Siemens Input Module 6ES7-131-4EB00-0AB0 11244

Siemens 6ES5 243-1AA13 6ES52431AA13

Siemens Output Module 6ES7 322-1FF01-0AA0

SIEMENS SIMADYN D 6DD3461-0AE0 CABLE SC60 34pin 2m !! QUANTITY!!

TLS-350 WPLLS Communication Module 330812-001

SIEMENS 6SN1118-0DJ21-0AA1

SIEMENS Simodrive 6 RA 2632-6DV55-ZY26 Drive Plus Cards

SIEMENS 6FC5357-0BB35-0AA0 | 12mo warranty | Free EU Shipping | Inc UK VAT

ADVANTECH PCL-849 PCL-849A RS-232 Comm Card

Allen-Bradley 1756-OB16E/A F Output Module

ABB Bailey Infi 90 INIPT02 Plant Loop Remote Transfer Module in the

ADEPT TECH 10171-00020 NSPP 1017100020

( ) SQUARE D ECONOFLEX ADJUSTABLE SPEED DRIVE CONTROLLER 58ENG4VY

HONEYWELL 945-L4Y-2D-001 NSFP 945L4Y2D001

TAYLOR ELECTRONICS 6214BZ10110G USPP 6214BZ10110G

DANFOSS VLT3504 USPP VLT3504

CONTROL TECHNIQUES M75R-14ICD USPP M75R14ICD

OMRON Z4M-T30V2 USPP Z4MT30V2

MODICON 557VIC12430 USPP 557VIC12430

GENERAL ELECTRIC TB63T600 USPP TB63T600

Siemens 6ES5 308-3UA12 -- 6ES53083UA12

Siemens 6ES5-521-8MB12 USPP 6ES55218MB12

SIEMENS 6ES5-318-8MC12 6ES5318 6ES5318-8MC12 PLC ET200U

Siemens 6ES5 100-8MA02 CPU Module Processor Unit WOW

Siemens 6ES5-246-4UA21/6ES52464UA21 Controller OFFERS ACCEPTED

Siemens 6GK7 243-1EX00-0XE0 6GK7243-1EX00-0XE0 in Box

Siemens TP177B 6AV 6642-0BA01-1AX1 Touch Glass

Siemens 6ES5615-0UB11

Kingspec Flash DOM Disk On Module 2GB/2G 44Pin Vertical IDE Interface PATA MLC

YASKAWA ELECTRIC JAMSC-B2110AV USPP JAMSCB2110AV

Siemens 6ES7 216-2BD22-0XB0 6ES7216-2BD22-0XB0 FreeShip

Siemens OP270 6AV6542-0CC10-0AX0 HMI Touchscreen

Red Lion DT3A0400

Schneider Modicon AS-B827-032 24 VDC Input ASB827032

Schneider Modicon AS-8535-000 NSFP AS8535000

Schneider Modicon AS-MBPL-500 USPP ASMBPL500

Schneider Modicon AS-B231-501

Schneider Modicon AS-212P-020 PC BOARD ASSEMBLY K

Modicon/Schneider PanelMate PM+ 1000 Modbus MMPMMP003C

SIEMENS SIMATIC TI305-01N INPUT 24 VDC MODULE TI30501N

Telemecanique Proximity Switch Sensor XS2-D12PA140C NIB

Siemens Simatic S5 6ES5451-8MD11 Output Module 8MD11 Refurbished

SIEMENS / TI 505-4908 RELAY OUTPUT MODULE

SIEMENS Sinumerik DMP Module Modul 6FC5111-0CA01-0AA0

SIEMENS 6SN1113-1AB01-0BA1 6SN11131AB010BA1

SIEMENS SIMODRIVE 6SN1123-1AB00-0HA1 with 6SN1118-0AE11-0AA1

SIEMENS NCU-BOX 6FC5247-0AA00-0AA2 SINUMERIK 840D/DE

ADVANTECH PCL-747+ CPU Module

Allen-Bradley 2711-M14 Monitor

ABB 57310001-MP

Acme T-2A-350012-3S 112.5 KVA 480 X 480/277 Volt Transformer - T295

Aaronia HyperLOG 30180 Antenna -

85051-60006 Beatty Standard; replaced by 85051-60011

SIEMENS 6GF3010-0HE15-0CS0 USPP 6GF30100HE150CS0

ASEA BROWN BOVERI QDBB-153M USPP QDBB153M

ASEA BROWN BOVERI 57360001-HG USPP 57360001HG

MITSUBISHI HC-H702S-A42 NSFP HCH702SA42

INDRAMAT KDF1.1-100-300-W1/220 USPP KDF11100300W1220

ALLEN BRADLEY 8600-1870X USPP 86001870X

SYMAX 8994-SYS80 USPP 8994SYS80

Siemens 6ES5-434-4UA12 INPUT MODULE

SIEMENS 6ES5 466-8MC11 -FS- 6ES54668MC11

SIEMENS INTERFACE MODULE 6ES5 305-7LA11

Siemens S5 6ES5 421-8MA11 6ES54218MA11 Dgital Input 24VDC

Siemens 6ES7 421-1BL00-0AA0 6ES7421-1BL00-0AA0 NIB

SIEMENS RWD44U Controller

PROLOG NDC-S911 NSPP NDCS911

HONDA iPOD iPHONE AUX INPUT INTERFACE CONNECTOR 08A28-iJi-100 MODULE USA SELLER

VERMONA QMI QUAD MIDI INTERFACE MODULAR EURORACK MODULE

Siemens 6AV7613-0AA13-0CF0 PC670 Membrane Keypad

Siemens LOGO USB Cable 6ED1 057-1AA01-0BA0 FreeShip

Omron 3G2A5-ID219

Schneider Modicon AS-P930-104 PLC

Schneider Modicon AS-P453-652 Remote I/O Power Supply

Schneider Modicon AS-EM85-301 NSPP ASEM85301

Schneider Modicon GOULD PROGRAM PACK AS-P371-002

Schneider Modicon AS-BDAP-209

Schneider Modicon Program Terminal w/ Keyboard AS-P190-212 with keyboard cover & key

Telemecanique ATV11HU09M3A 0.37kW Inverter in Box

Schneider Telemecanique Contactor LC1D09 M7C

Siemens6ES7222-1EF00-0XA0EM222OutputModule

Siemens 6AV6542-0BB15-2AX0 6AV6 542-0BB15-2AX0 SIMATIC OP170B 5.7 Keypad Panel

SIEMENS SINUMERIK 6FC 3671-0FB-Z CONTROL RACK

GE FANUC IC600CB516M COMMUNICATION MODULE

SIEMENS SINUMERIK 6FC3538-3EF 6FC35383EF USED

SIEMENS MOORE CO. MODEL 63BD-L DIFFERENTIAL TYPE FLOW CONTROL

ALLENBRADLEY FLEX I/O ANALOG OUTPUT MODULE CAT:1794-OF4I

AB Allen Bradley PowerFlex 400 22C-D105A103 Ser A 75 HP

AC Motor Control Drive - 60 HP - 480 Volt - Three Phase Input

A06B-0511-B001#1000 FANUC SERVO MOTORS REMANUFACTURED

75 Ton Liqui-Chill Chiller '95

RELIANCE ELECTRIC 86466-74RB USPP 8646674RB

ALLEN BRADLEY 500-GOB-930 USPP 500GOB930

ALLEN BRADLEY 1785-L40B/E NSPP 1785L40BE

INDRAMAT DDC01.2-N200A-DS50-01-FW USPP DDC012N200ADS50A

YASKAWA ELECTRIC CACR-IR10101FC USPP CACRIR10101FC

WARD LEONARD 5DP8-20100 USPP 5DP820100

HONEYWELL 30752387001 NSPP 30752387001

Siemens 6ES5-243-1AA11 USPP 6ES52431AA11

SIEMENS 6ES5 376-0AA21 6ES53760AA21

SIEMENS Digital Output Module 6ES5 521-8MA21 Version 1 Appears to be

Siemens 6GK1143-0AA01 /6GK1-143-0AA01/6GK11430AA01 Comm Module OFFERS ACCEPTED

Siemens 6ES5921-3UA12 IN BOX

Siemens MP277-8 6AV6 643-0CB01-1AX1 Protective Film

RELIANCE ELECTRIC 0-57405 USPP 057405

Texas Instruments 500-5828A

SQUARE D S48891 MOD DIFF GROUND FAULT INTERFACE MODULE

UNIPRO 24002156 USPP 24002156

Siemens CB24 COM BOARD 6RX1240-0AK01

Modicon AS-W904-050

Schneider Modicon 3038DEP216/AS-BDEP-216 Input Module

Schneider Modicon S911 PROCESSOR MODULE AS-S911-801

Schneider Modicon AS-BDAU-202 2 Point Output Module

Schneider Modicon AS-BDAP-204 Compact Out Module ASBDAP204

Schneider Modicon /Schneider AS-B873-011/AB873011 NICE

Schneider Modicon Compact AS-BDAP-216 ASBDAP216 DC Output NIB

Schneider Modicon TSXPCX1031-C TSXPCX1031C PLC Cable

SCHNEIDER TSX COMPACT DISCRETE INPUT FAST INPUT MODULES DEP 220/AS-BDEP-220

RADISYS EXM18-RS422 USPP EXM18RS422

SIEMENS 6ES5-456-7LA11/6ES5456-7LA11 OUTPUT MODULE NIB

SIEMENS SINUMERIK OP010 6FC5203-0AF01-0AA0 MembraKeypad

Mitsubishi F2-20GF Communication Module Free Ship

SIEMENS Simodrive 6SN1118-0DG22-0AA0 E GWE-567008901365

SIEMENS Sinumerik FM 6FC5210-0DA00-1AA1 6FC5 210

SIEMENS 6FC5203-0AB00-0AA0 Sinumerik OP030 Free Ship

ALLENBRADLEY1734-0B8STANDARDSOURCEOUTPUTMODULE8CHANNEL24VDC1A/24VA

Allen Bradley SLC 500 1747-L20A Series B Processor with 2 Output Modules

ABB ROBOT TRALLFA TEACH PENDANT 3E031712 TESTED &

A06B-0143-B175#7008 FANUC SERVO MOTORS REMANUFACTURED

00415 GE IC640MWS902A Demo Unit

MOORE PRODUCTS 39ACM28ADN USPP 39ACM28ADN

ALLEN BRADLEY 150B97NBD8L NSPP 150B97NBD8L

ALLEN BRADLEY 1326AS-B440G-21-K4 USPP 1326ASB440G21K4

GENERAL ELECTRIC 36C774505ABG01 USPP 36C774505ABG01

SQUARE D KCL341252361 NSFP KCL341252361

SIEMENS 6SC-9811-4BF54 USPP 6SC98114BF54

ASEA BROWN BOVERI APSAF-03 USPP APSAF03

Siemens 6ES5 943-7UB21 6ES59437UB21

Siemens Simatic S5 6ES5 465-4UA11 6ES54654UA11 Analog

SIEMENS 6ES5-700-3LA12 USPP 6ES57003LA12

Siemens 6ES5 460-4UA12/6ES54604UA12 Analog Input

Siemens 6AG1 223-1PL22-2XB0 6AG1223-1PL22-2XB0 FreeShip

Siemens IGBT BSM75GB120DN1E3204

SANS DIGITAL MR4UT 4-bay hot-swap hardware RAID storage

Square D SERIPIEX SET-UP TOOL

SIEMENS INTEL HTRI-D DUAL INTERFACE MODULE BRAND NEFREE SAME DAY USA

SERIES C F/W REV A PKG 06/09/2009

Siemens 6SE7022-6EC61

Siemens TXB1.P1

Schneider Modicon Compact AS-PRTU-252 ASPRTU252 NIB